About Us Manure Management Equipment Bio-Augmentation Products Animal Health Products

• Highly effective -integriSTAT can be highly effective at decreasing the incidence of Hairy Heel Warts when used as recommended.
•  Non-Toxic - Unlike many hoof bath treatment agents that are highly toxic to humans and the environment, integriSTAT in non-toxic, environmentally friendly, non-cumulative and enhances biological activity in the lagoon and soil.
• Safe - Use only standard precautionary measures when handling such as eye and skin protection.
•  Economical - After the Control Phase of the integriSTAT Three Step Program, the amount of integriSTAT required to maintain healthy hooves is often decreased significantly by reducing the concentration or number of cow exposures per week. Healthy hooves mean more milk, a better breeding program, fewer labor inputs and less medical intervention.
•  Convenient - An aqueous solution that mixes easily with water saving time and effort.

The integriSTAT 3 Step Program:

• Five baths per week for one (1) week only = 5 exposures per cow
• The objective is an intensive exposure for a brief period of time

• Three baths per week for six (6) weeks = 18 exposures per cow
• The objective is a controlled reduction in the number of warts to the point of virtual elimination

• Two or fewer baths per week and/or lower dose of IntegrSTAT per gallon of water
• The objective is a slow, systematic reduction in the number of cow exposures or the amount of IntegriSTAT concentrate being used in the bath in order to achieve the desired level of hoof health at the greatest economy

Important Disclaimer - The IntegriSTAT 205 Three Step Program is a GUIDELINE based upon extensive use trials and experience. In many cases, Hairy Heel Warts have been dramatically reduced and in some cases virtually eliminated from the herd. In some cases, perhaps where the suggested Guidelines for use were not observed, it was not effective. The benefits of replacing toxic hoof health management products with IntegriSTAT 205 are compelling and worthy of the attention it takes to execute the Program properly. If, however, IntegriSTAT 205, for whatever reason, fails to meet your objectives and expectations, discontinue use immediately.

Important - Do not mix integriSTAT with other chemicals or hoof bath additives. Use only in a clean hoof bath. If you have been using copper sulfate, the hoof bath should be pressure washed and free of any copper residual. Do not use more than two ounces per gallon.

Measure hoof bath in inches. Multiply Width by Length by Depth. Divide by 231 (there are 231 cubic inches per gallon). This equals the capacity of the hoof bath in gallons.

Example: Hoof bath size is 4' X 6' X 5" deep (liquid level when full). So 48" X 72" X 5" = 17, 280 cubic inches divided by 231 cubic inches per gallon = 75 gallons. At the dosage rate of 2 ounces of IntegriStat per gallon of water, 150 ounces are needed to dose correctly.

Universities recommend 3 to 5 cow passes per gallon of hoof bath volume before dumping the dirty bath and refilling. One cow passing through the hoof bath is a single "cow pass". To determine the number of cow passes per gallon, divide the number of cows between bath refills by the number of gallons in the bath.

• 250 cows through a 50 gallon bath = 5 cow passes (250÷50=5)
• 300 cows through a 50 gallon bath = 6 cow passes (300÷50=6)
• 80 cows through a 30 gallon bath = 2.7 cow passes (80÷30=2.7)

exp/wk = exposures per cow per week

• 2 cow passes per gallon = 1 oz. of IntegriSTAT consumed per cow pass
5exp/wk = 5.0 oz./cow 3exp/wk = 3.0 oz./cow 2exp/wk = 2.0 oz./cow 1exp/wk = 1.0 oz./cow
• 3 cow passes per gallon = .66 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 3.3 oz./cow 3exp/wk = 1.98 oz./cow 2exp/wk = 1.32 oz./cow 1exp/wk = 0.66 oz./cow
• 4 cow passes per gallon = .50 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 2.50 oz./cow 3exp/wk = 1.50 oz./cow 2exp/wk = 1.0 oz./cow 1exp/wk = 0.50 oz./cow
• 5 cow passes per gallon = .40 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 2.0 oz./cow 3exp/wk = 1.2 oz./cow 2exp/wk = 0.80 oz./cow 1exp/wk = 0.40 oz./cow
• 6 cow passes per gallon = .33 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 1.65 oz./cow 3exp/wk = 0.99 oz./cow 2exp/wk = 0.66 oz./cow 1exp/wk = 0.33 oz./cow
• 7 cow passes per gallon = .28 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 1.4 oz./cow 3exp/wk = 0.84 oz./cow 2exp/wk = 0.56 oz./cow 1exp/wk = 0.28 oz./cow
• 8 cow passes per gallon = .24 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 1.2 oz./cow 3exp/wk = 1.08 oz./cow 2exp/wk = 0.48 oz./cow 1exp/wk = 0.24 oz./cow
• 9 cow passes per gallon = .22 oz. of IntegriSTAT consumed per cow pass

5exp/wk = 1.1 oz./cow 3exp/wk = 0.99 oz./cow 2exp/wk = 0.44 oz./cow 1exp/wk = 0.22 oz./cow

• 180 cows with a 30 gallon bath = 6 cow passes per gallon of bath (180cows÷30=6 cow passes) @ 3 exposures (baths) per week

.99 oz/cow X 180 cows = 178.2 oz integriSTAT ÷ 128 = 1.39 gallons/wk 6.02 gallons/month

• 250 cows with a 50 gallon bath = 5 cow passes per gallon of bath (250÷50=5) @ 2 exposures (baths) per week

.8 oz/cow X 250 cows = 200 oz integriSTAT ÷ 128 = 1.56 gallons/wk 6.76 gallons/month

• 750 cows with a 50 gallon bath with 250 cows between refreshing the bath = 5 cow passes/gallon (250÷50=5) @ 3 exposures (baths) per week

1.2 oz/cow X 750 cows = 900 oz integriSTAT÷ 128 = 7 gallons/wk 30 gallons/month

• 2,200 cows with a 80 gallon bath with 500 cows between refreshing the bath = 6 cow passes/gallon (500÷80=6) @ 2 exposures (baths) per week

.66 oz/cow X 2,200 cows = 1,452 oz IntegriSTAT ÷ 128 = 11.34 gallons/wk 49 gallons/month